Design, Dimensions, Layout

Steel Construction

Painting System

Engine Room Equipment, Pumps

Propulsion


Hydraulic System


Tanks & Piping System


Anchorage & Mooring

Windows, Doors, Hatches, Ports


Insulation


Electrical System


Interior, Wood work

• Wood work
• Galley
• Heads
• Deck
  

Safety

Sail Plan

Electronics

Ventilation

DIESEL DUCK 47 PLUS DESIGN (GEORGE BUEHLER) Design, Dimensions, Layout

SEAWORTHY DELIVERY CONDITION:

UNDER MAIN DECK: As indicated Buehler Lay-out

- 1 Aft Master cabin
- 1 Livingroom
- 1 forward cabin
- Kitchen arrangement in passageway
- Isolated Engine room
- Toilet, bathroom

MAIN DECK:

- Pilot house and sitting saloon

• Forward slanting windows
  
• Roof edging to be explained later

AFTER DECK:

• Built in storage locker
• Double propane locker for BBQ and galley stove.
  

Aft well sitting system (open area)

STEEL CONSTRUCTION HULL

- Buehler design 47 plus, single chine. Steel construction boat
- Marine Grade A certificated steel plates.
- Weld xray
- CE class A Offshore certificated
- Collision and engine room, water tight steel bulkheads.
- Water and fuel body tanks
- Steel superstructure, Pilot house and aft pool construction
- Aft built-in swim platform and stair-steps as your required
- Epoxy painted steel pipe hand rails as Buehler spec
- Sail rig and steel painted mast as Buehler spec

PAINTING SYSTEM Commercial Grade Epoxy

- All steel construction materials (shot blasted and shop primer epoxy painted )
- All outside and inside surfaces 3 layers anti-corrosion epoxy painting.
- Underwater surfaces 2 layers antifouling epoxy paints
- 2 layers colour synthetic paint on superstructure surface. Owner choice.(Red)
- Wear resist commercial deck paint and Non-skid walk ways on main deck
- 3 layers epoxy painted hand rails , etc on deck

ENGINE ROOM EQUIPMENT AND PUMPS

- 150 HP IVECO 6 cyl marine diesel natural aspirated main engine. Goerge advices 125 HP.
- Exhaust silencer , Wet exhaust system
- Fuel racor fitler with water seperator (secondery)
- ZF Gear box 2.5:1 ,with elastic coupling
- Seawater suction chest and valves.
- Electro mechanic connected hydraulic power unit (connected to engine)
- Fire pump
- High output alternator 100 amp connected to engine
- Electric bilge pump, 3 auto bilge pumps
- Heat exchanger from main engine
- Workbench
- Ventilation including large engine room exhaust blower, vented to roof.
- Easy access to Universal joint and prop shaft

PROPULSION

- 50-60 mm diameter 316 grade stainless propeller shaft. Dia of the shaft will be calculated exactly later.
- Seamless steel stern tube.
- 4 blades Aluminium bronze propeller
- Wet type rubber shaft bearings
- Rubber dripless Deep Sealing
- Elastic coupling
- Stainless rudder assembly & steel rudder

• Articulated steel rudder
• Emergency rudder post steering arm

- Heat exchanger from main engine

• Hot water heater connected to engine for warm up in freezing conditions

HYDRAULIC SYSTEM

- Hydraulic power unit connected to engine for steering
- Manuel hydraulic pump and steering control system

TANK AND PIPING SYSTEM

- Epoxy coated ,Steel freshwater tank As Buehler design.
- Main engine fuel tank
- Plastic dirty water tanks
- 24 V DC fresh and seawater pressure system for wc, shower, kitchen
- Bath,toilet kitchen and aft pool piping and armatures.
- Fuel piping from tank to engine and return
- Fuel and fresh Water tanks to have closable external sight valves. Water tanks to have
- Dirty water drains from bath and kitchen to dirty tank and MARPOL overboard system.
- Black water tanks to have separate intake and outlet vents
- Lavac manual toilet x 2
- BBQ, Range, clotes drayer propan pipe connections
- Range, with 2 or 3 propane and one electric element
- Under counter mounted microwave convection oven

ANCHORAGE & MOORING SYSTEM

- Electric driven windlass with vertical 2 drums (for chain and rope ) Vetus or Lofran
- Self storing anchor winch,bow anchor. With 10 mm diam galvanized 200 mt steel wire for anchor, with 30mt long and 12mm diam galvanized chain... Aft anchor with 100 mt 18 mm diameter 100 mt nylon rope. Bow and aft high strong stainless steel bollards . 6 pcs fender.
- 120 lb plow style anchor, 70 lb anchor, 40 lb Fortress ( your choice )
- Stainless steel anchor rollers

WINDOWS, GLASSES, DOORS HATCHES

- Commercial ship type aluminium Windows frames and aluminium or steel painted water tight dogged deck doors , lockable from inside and out
- 10 mm tempered glasses
- Hatches on cabin and saloon tops, locked from inside.. 3 commercial grade deck hatches (aft cabin-1, saloon-1 butterfly, forward cabin-1)
- Front screen wipers with wash



INSULATION

- All Interior walls covered by polyurethane foam spray insulating or block isolation materials against heat and noise
- All ceiling and complete pilot house foam block insulated against heat.
- Heat and noise resistance ceilling-side covered insulating in engine room.
- Main deck isolation material will be negotiated once again

ELECTRIC SYSTEM

- 24 volt 450 A/H. AGM Stationer battery bank
- 2 x Separate battery for main engine
- Batteries, inverter/charger, isolators located outside of engine room
- 24 V DC horn and screen wipers
- DC outlets in pilothouse, galley, salon, aft cabin.
- 24 V interior lighting and navigation lights
- 24 V 3 pcs bilge pump
- 110/220 V A/C – 24 V D/C redressor , battery charger
- 1000W inverter / charger compatible with shore 50hz and 60hz
- Shore power 50 amp service with GFI, 15 m. 50 amp cord
- Shore connection panel ,24 volt power panel,24 volt lighting and emergency lighting panel , 24 engine control and alarm panel , navigational lights panel
- 24 V D/C ventilation fans &panel (engine, cabin, salooon, bath, kitchen.)
- Stair courtesy lighting
- Red LED night lighting in pilothouse
- Zincs bolted on hull

INTERIOR AND WOOD WORK

- Aft master cabin & living room,forward cabin.
- Interior walls and ceillings will be covered with selected 8mm best guality marine ply wood. Face will be light colour but all rounds will be massive mahogany.
- All trim in mahogany
- Teak safety handholds on ceilings through out
- Interior floors will be covered marine type carpet.
- Queen size bedin master cabin.
- Wardrobe, drawers, tables, sitting group in cabin and where applicable
- Curtains and upholstery in saloon , colour Owner choice.
- Propane stove
- Cushions, mattresses and curtains, local material, your color choice

Galley :

- Table,cupboard,satainless counter top and other furnitures,As indicated in spec or owner choice
- Corian type counters, your color choice
- 24V middle size refrigerator on eng room bulkhead.
- 3 propane burner, 1 electric burner
- Propane oven,
- Single stainless sink and water taps , etc
- Propane control panel with auto shutoff and alarm
- Ventilation fan over range

WC –2, fwd and aft :

- Marine LAVAC manual toilets
- Polyester shower pool and cabin with bench seat over convexity of hull, fwd and in Master cabin.
- Washbasin , buit-in miror
- Shower hot-cold water fixture and cabin drainage system
- 24 V D/C ventilation fan and lighting system.
- Overhead and under sink storage cupboards

Pilot house :

- Light colour faced Marine plywood walls, massive mahogany wood rounded Windows and furnitures
- Mahogany Chart table and control dash panel
- Quality Wood or brass, satinless steering Wheel.
- Reading lights
- Small fan at helm and navigation desk
- Sitting group and upholstery. Quality and colour owner choice
- Captains Bed
- Proper good quality pilot chair.
- Curtains, bed and bed sheet

SAFETY

- Life jackets 6
- Throw rings 2
- Flares
- First aid kits
- CO2 fire extinguisher (6 ).
- Engine room, cabin, galley, saloon smoke detectors and fire alarm panel.
- Alarms: engine temperature, engine water flow, low oil pressure, engine room temperature, bilge high water, pump running, engine room light on,
- Search light forward
- Navigation lights
- Aft deck light
- Sea chest with strainer (single underwater through hull for all incoming water)
- Ball valve seacocks throughout

MAST AND SAIL RIG BUEHLER SPEC (As per George Buehler spec)

- Epoxy painted steel mast.
- Steel galvanized stays and wires, stainless lifting
- Manuel rope winches.
- Main sail

NAVIGATIONAL ELECTRONICS

- Furuno or Ray Marine C80 8.4'' color 2 KW radar, plotter,
- GPS + Autopilot
- Wind indicator

VENTILATION

- Engine room: intake and exhaust vents to pilothouse roof. Exhaust fan.
- Saloon: 2 x Dorade vents with covers
- Heads: 2 x exhaust fans on automatic timers
- Black water waste tanks: 2 x both freshair intake and vent pipes
- Freshwater tanks with upside down "U" vents to prevent salt water entry to tanks
- Electric fans in forward stateroom x 2, aft stateroom x2, pilothouse x2
- Portholes that open (with storm covers)
- Galley: Range hood fan exhaust